Transmission Tv Cable Adjustment

If you are unsure about the proper adjustment needed call the monster transmission tech line for help or refer to a general motors service manual for additional information and reference.

Transmission tv cable adjustment.

Erik shows you how to adjust the tv cable properly after installing it in his 58 chevy the black widow. Cable disconnected pull the link out of the transmission and fit the cable end to the link as shown in figure 1. How to adjust the tv cable throttle valve cable for your 700r4. Too short is less throw so it keeps the tv plunger in the sleeve further in higher pressure at idle with the same wot.

Tv cable bottomed out at wot. Permanent damage will occur within a few feet of driving if the tv cable is not hooked up or improperly adjusted. The aod transmission may feel like it is shifting at the right time when the tv cable is actually way off. It is imperative that after your new monster 700r4 2004r transmission has been installed that the throttle valve tv cable gets adjusted properly damage will occur to the transmission voiding the warranty.

Push the tv cable sheath into the seal in the transmission and tighten the 10mm retaining bolt. Aod throttle cable fix and adjust. The transmission will work for a while and then fail. Don t think of it as just a kick down cable on the nonvacuum modulated th700r4 and th2004r the tv cable controls line pressure shift points shift feel part throttle downshifts and detent downshifts.

It is better to be slightly too short on the cl to cl measurement than too long. That will keep the trans alive and more often then not you will have to back off the adjustment a click or two. If your vehicle has a factory installed bracket for the tv cable then skip to step 4. Proper installation and adjustment of the tv cable is the most important aspect of a transmission.

Step 3 install a bracket that will allow the tv. The throttle valve tv cable is an item that is not present on the current generation of. Ford aod automatic overdrive lift tab type tv cable adjustment.